I heard that the skylight of the owner of Xiaoqi leaked, so my Chinese doctor came to operate._vehicles, vehicles

I heard that the skylight of the owner of Xiaoqi leaked, so my Chinese doctor came to operate.

September 20, 2024

I batch Xiaoqi in September 2017, which was considered the second batch in mass production. Unfortunately, the skylight leaked, and the A-pillar was soaked and flowed out of the ceiling.
Take some free time to open it.

The process omitted 24 hours…

The built-in order is from top to bottom, so the disassembly order is from bottom to top.

There are fewer wiring harnesses in the ceiling, including four light strips at the four corners of the sunroof, one rear reading light on the left and right, and one sunroof controller in the center. We can completely remove and move out of the ceiling by cutting them one by one.

The traces of leakage left in the ceiling, look for the leakage point.

Looks like it’s here.

Looking up at the sky, I found traces of water stains.

It turns out that it was a clerical error by Zhongtai chicken archer. The skylight and wind-blocking curtain groove are transparent from top to bottom??””””

Light is shining…

Make an interruption and make a ceiling soundproof… (Wait for the horse cake materials…)

108 hours later…

First, we will deal with the problem of peeling the stainless steel felt layer between the lower ceiling and the inner ring of the skylight.

It’s okay, it’s stuck.

Put cotton on, and the corner where the dumbbells are put is good for the dry brothers

It was completed in 24 hours. Cut out the thread ends and screw holes.

Make a tailgate and cut off sound insulation

Make a B-pillar reinforcement

I repair skylight, how could I stray from the topic…

Look at the dust in this small grid at the corner and you can tell how much rain this place has experienced.

The method to remove the wind-blocking curtain is to use a small screwdriver to lift it up from the lower small grid and top it up. Insert more than a dozen small grids one by one and top it again. There are grooved hanging openings inside, paying attention to protecting raw materials.

Then, after dismantling, you will find so many small compartments with transparent top and bottom, and seal them with transparent tape from the inside.

For glue filling, I used 705 silicone that used to block the toilet floor drain. I drove a duck to the shelves and treated a dead horse like a dead horse. Don’t tell me what glue to use.

Pour it all…

seven
seven
second
ten
a
a
small
when
After………
Replace the wind blocking curtain
,, rain test, burn incense and ask for heavy rain when it is sunny. Test it.
Old Chinese medicine practitioners have always adhered to the spirit of tearing it down first and then talking about it, and provided everyone with their methods and experience free of charge. We don’t ask for after-sales services anymore.

Recommended Suppliers

Hot Information

Tesla Autopilot and similar automated driving systems get ‘poor’ rating from prominent safety group

April 1, 2024

JCTSL may turn bus stands into charging points for e-buses

March 27, 2024

Localization of EV parts without production scalability may not help cut EV price, says President, Amara Raja

March 27, 2024

Vehicles

Tyre

Auto Spareparts

Material

Const machinery & Agro equipment

I heard that the skylight of the owner of Xiaoqi leaked, so my Chinese doctor came to operate.